螺旋输送机,皮带输送机,链板输送机生产厂家
销售热线:15090417350
输送设备/饲料厂专用链式输送机

产品附件:
提升机是应用最广泛的一种垂直提升设备,该机适用于中、大块和有磨琢性的物料(如石灰石、水泥熟料、石膏、块煤)的垂直输送,物料温度在250℃以下。
NE型板链斗式提升机是由国外引进先进技术研制的新产品,主要技术参数符合机械部标准(JB3926-85)。采用自流式装料,重力式卸料.链条是优质合金钢高强度板式链条,耐磨而可靠。驱动部分采用硬齿面减速器。NE系列板链式斗式提升机共有11种型号:NE15、NE30、NE50、NE150、NE200、NE300、NE400、NE500、NE600、NE800。
NE系列板链斗式提升机工作原理:
NE系列板链式斗式提升机本机系流入式喂料,物料流入料斗内靠板链提升到顶端,在物料重力作用下自行卸料。本系列提升机规格多(NE15~NE800共11种)提升量广;且生产能高,能耗较低,可逐步代替其他类型提升机,其主要参数见下表。该机采用全封式机壳链速低,几乎无回料现象,因此无功功率损耗少,噪声低,寿命长。
NE系列板链斗式提升机主要结构:
NE系列板链式斗式提升机由运行部件、驱动装置、上部装置、中部机壳、下部装置组成。
运行部件---由料斗和专用板式链条组成,NE30以及下采用单排链,NE50--NE800采用双排链。
驱动装置---采用多种驱动组合驱动,(依用户实际需要而定).驱动平台上装有检修架和栏杆。驱动制装置分左和右装两种。
上部装置---安装有轨道(双排链)、逆止器、卸料口装有防回料橡胶板。
中间节---部分中间节装有轨道(双链),以防止链条工作中摆动。
下部装置---安装有自动张紧装置。
NE系列板链斗式提升机主要特点:
1.密封性好,环金污染少。
2.操作、维修方便、易损件少。
3.使用成本低,由于节能和维修少,使用成本极低。
4.运行可靠,先进的设计原理,保证整机运行的可靠性,密封性好。环境污染少。
5.结构港型号,精度高。机壳经折边和中间压筋,再经焊接,刚性好、外观漂亮。
6.机械尺寸小,与同等提升量的其它各种提升机相比,这种提升机的机械尺寸较小。
7.输送能力大,该系列提升机具有NE15~NE800多种规格。提升量范围为15~800m3/h。
8.操作方便,维修少,易损件少。输送链为套筒滚子链,诱导式重力卸料,用于各种粉状、块状物粒的垂直提升。
NE系列板链斗式提升机主要部件特点:
1.上部装置:安装有轨道(双排道),防止链条摆动,逆止器,防止料斗回转,物料阻满下部机壳,卸料口装有橡胶板防止回料。
2.中间节:部分中间节装有轨道(双排节),以防止链条工作中摆动,部分中间节装有检修门以便维修。
3.下部装置:安装有张紧装置, NE15~NE50采用弹簧张紧,NE100~NE800采用重锤箱张紧。
4.上下链轮采用 ZG310-570。整体调质,HB229-269齿面淬火HRC40~48。
5.板链:链板采用 45 # HRC36~42
 
 
新乡市宏源振动设备有限公司输送机
联系人:房经理
电话: 0373-2678162
传真:0373-2678162
手机:15090417350 15993019510
地址:河南省新乡市宏力大道北段冀场工业区输送机厂 宏源振动 输送机
网址:http://www.xxyhzd.com
 
推荐产品:
推荐阅读:
产品导航:
 

Hoist is the most widely used a vertical lifting equipment, the machine is suitable for use in large, and wear resistance of material ( such as limestone, gypsum, cement clinker, coal ) vertical conveyor, material temperature under 250 DEG c..

NE type plate chain bucket elevator is by the introduction of foreign advanced technology development of new products, the main technical parameters with the machinery of the standard ( JB3926-85). Using a gravity type charging, gravity discharge. The chain is of high quality alloy steel high strength plate chain, durable and reliable. The driving part adopts hardened-gear speed reducer. NE series plate chain bucket type lifting machine has 11models: NE15, NE30, NE50, NE150, NE200, NE300, NE400, NE500, NE600, NE800.

NE series plate chain bucket type lifting machine principle of work:

NE series plate chain bucket elevator the machine into the feeder, material flows into the hopper by plate chain lift to the top, in the material under the action of gravity to discharge. This series of elevator specifications ( NE15 ~ NE80011) promote wide; and the production of high, low energy consumption, can gradually replace other types of hoist, its main parameters in the table. The machine adopts the full sealing type casing of chain speed low, almost no feed back phenomenon, so the reactive power consumption, low noise, long life.

NE series plate chain bucket elevator main structure:

NE series plate chain bucket elevator components from running, driving device, the upper device, the central case, the composition of the lower device.

The moving parts - from the hopper and special chain plate composition, NE30 and single row chain, NE50--NE800adopts a double chain.

Drive driver combinations using a variety of driving, ( depending on the actual needs of users ). Driven aircraft maintenance platforms and railings installed. Drive system device installed at the two left and right.

The upper device installation track ( double chain), backstop, discharging outlet provided with an expected to rubber plate.

The middle section - part of the middle section with the track ( duplex ), to prevent the work of swinging the chain.

The lower device installation of automatic tensioning device.

NE series plate chain bucket elevator main characteristics:

1good sealing, ring gold less pollution.

2operation, convenient repair, less wearing parts.

3the use of low cost, energy saving and less due to repair, low cost.

4reliable, advanced design principle, ensuring the operation reliability, good sealing performance. Little environmental pollution.

Hong Kong5structure models, high precision. Casing the hems and intermediate pressure bar, after welding, good rigidity, beautiful appearance.

6 machine of small size, and the same amount of lift of the various other than the hoist, hoist mechanical size small.

7large conveying capacity, the series of lifting machines have a variety of specifications NE15~ NE800. Lifting weight range of 15~ 800m3 / h.

8convenient operation and repair, less, less wearing parts. Conveying chain for the sleeve roller chain, induced gravity discharge, for all kinds of powder, bulk grain vertical lifting.

NE series plate chain bucket elevator main components characteristics:

1: upper device mounted track (double tract ), prevent the chain swing, backstop, prevent hopper rotary, material resistance with lower case, discharge mouth is provided with a rubber plate to prevent the return of material.

The 2 intermediate sections: part of the middle section with the track (double section ), to prevent the work of swinging the chain, part of the middle section with the access door to repair.

3: lower device mounted with tensioning device, NE15 ~ NE50 uses spring tension, NE100 ~ NE800 using heavy box tensioning.

4sprockets using ZG310-570. Overall conditioning, HB229-269tooth surface quenching of HRC40 ~ 48.

5: chain plate chain plate adopts45# HRC36 ~ 42

Xinxiang City Hongyuan vibration equipment limited company conveyer

Contact: the real manager

Phone:0373-2678162

Fax:0373-2678162

Mobile phone:1509041735015993019510

Address: Henan province Xinxiang City Grace Avenue North Industrial Zone Hebei field conveyer factory Hongyuan vibration conveyer

Website: http : / / www.xxyhzd.com

【点击返回首页】

联系我们

新乡市宏源振动设备有限公司
联系人:房经理
电话:0373-2678162
传真:0373-2610889
手机:15090417350
地址:河南省新乡市宏力大道西段西冀场——输送机厂家 宏源振动 输送机 螺旋输送机 皮带输送机 链板输送机
网址:http://www.xxyhzd.com